logo

Safety Data Sheet (SDS)

SDS #: 401.5
Revision Date: March 21, 2014
SECTION 1 — CHEMICAL PRODUCT AND COMPANY IDENTIFICATION

Immersion Oil High and Low Viscosity

Flinn Scientific, Inc. P.O. Box 219, Batavia, IL 60510 (800) 452-1261
Chemtrec Emergency Phone Number: (800) 424-9858
Signal Word
WARNING
SECTION 2 — HAZARDS IDENTIFICATION
Hazard class: Skin and serious eye damage, corrosion or irritation (Category 2, 2A). Causes skin and serious eye irritation (H315+H319).

Hazard class: Specific target organ toxicity, single exposure; respiratory tract irritation (Category 3). May cause respiratory irritation (H335). Avoid breathing mist, vapors or spray (P261).
Pictograms
SECTION 3 — COMPOSITION, INFORMATION ON INGREDIENTS
Component Name CAS Number Formula Formula Weight Concentration
Immersion oil

Synonyms: Cargille Type A or Type B
None established Proprietary Proprietary
SECTION 4 — FIRST AID MEASURES
Call a POISON CENTER or physician if you feel unwell (P312).
If inhaled: Remove victim to fresh air and keep at rest in a position comfortable for breathing (P304+P340). If aspirated into lungs: Immediately call a POISON CENTER or physician. If in eyes: Rinse cautiously with water for several minutes. Remove contact lenses if present and easy to do so. Continue rinsing (P305+P351+P338). If eye irritation persists eyes: Get medical advice or attention (P337+P313). If on skin: Wash with plenty of water (P302+P352). If skin irritation occurs: Get medical advice or attention (P332+P313). If swallowed: Do NOT induce vomiting. Call a POISON CENTER or physician if you feel unwell.
SECTION 5 — FIRE FIGHTING MEASURES
Combustible when exposed to heat or flame.
Flash point: greater than163 °C
In case of fire: Use a tri-class dry chemical fire extinguisher.
NFPA Code
None established
SECTION 6 — ACCIDENTAL RELEASE MEASURES
Contain the spill with sand or absorbent material and deposit in a sealed bag or container. See Sections 8 and 13 for further information.
SECTION 7 — HANDLING AND STORAGE
Flinn Suggested Chemical Storage Pattern: Organic #3. Store with hydrocarbons, oils, esters and aldehydes.
Store away from direct sunlight between 18 and 32 °C. Keep container tightly closed (P233). Use only in a hood or well-ventilated area (P271).
SECTION 8 — EXPOSURE CONTROLS, PERSONAL PROTECTION
Wear protective gloves, protective clothing, and eye protection (P280). Wash hands thoroughly after handling (P264). Use only in a hood or well-ventilated area (P271).
Exposure guidelines: TLV 4.9 mg/m3 as hydrogenated terphenyls (ACGIH)
SECTION 9 — PHYSICAL AND CHEMICAL PROPERTIES
Pale yellow or colorless oily liquid. Characteristic odor.
Soluble: Organic solvents. Insoluble in water.
Melting point: >300 °C
SECTION 10 — STABILITY AND REACTIVITY
Shelf life: Indefinite, if stored away from direct sunlight, between 18 and 32 °C.
SECTION 11 — TOXICOLOGICAL INFORMATION
Acute effects: Skin, eye, and respiratory tract irritation.
Chronic effects: N.A.
Target organs: N.A.
ORL-RAT LD50: N.A.
IHL-RAT LC50: N.A.
SKN-RBT LD50: N.A.
SECTION 12 — ECOLOGICAL INFORMATION
Data not yet available.
SECTION 13 — DISPOSAL CONSIDERATIONS
Please review all federal, state and local regulations that may apply before proceeding.
Flinn Suggested Disposal Method #18b is one option.
SECTION 14 — TRANSPORT INFORMATION
Shipping name: Not regulated. Hazard class: N/A. UN number: N/A.
SECTION 15 — REGULATORY INFORMATION
Not listed.
SECTION 16 — OTHER INFORMATION
This Safety Data Sheet (SDS) is for guidance and is based upon information and tests believed to be reliable. Flinn Scientific, Inc. makes no guarantee of the accuracy or completeness of the data and shall not be liable for any damages relating thereto. The data is offered solely for your consideration, investigation, and verification. The data should not be confused with local, state, federal or insurance mandates, regulations, or requirements and CONSTITUTE NO WARRANTY. Any use of this data and information must be determined by the science instructor to be in accordance with applicable local, state or federal laws and regulations. The conditions or methods of handling, storage, use and disposal of the product(s) described are beyond the control of Flinn Scientific, Inc. and may be beyond our knowledge. FOR THIS AND OTHER REASONS, WE DO NOT ASSUME RESPONSIBILITY AND EXPRESSLY DISCLAIM LIABILITY FOR LOSS, DAMAGE OR EXPENSE ARISING OUT OF OR IN ANY WAY CONNECTED WITH THE HANDLING, STORAGE, USE OR DISPOSAL OF THIS PRODUCT(S).
Consult your copy of the Flinn Science Catalog/Reference Manual for additional information about laboratory chemicals.